|
PLEASE PATRONIZE OUR SPONSORS!
|
|||||||
 |
|
|
Thread Tools | Display Modes |
|
#1
10-21-2016, 11:59 PM
|
||||
|
||||
1772 dies / fuel delivery issues?
I have been having some issues with my Kubota powered 1772. I have been prepping 1/2 acre of land to seed into lawn. The other day while pulling a section of rotary hoe, the tractor died...just like you shut it off.
I thought it might be out of fuel, but tank was 1/2 full. It started right off. But, it died another 4 or 5 times in an hour or so. Each time it re-started, pretty much with no problem. However, I felt like it didnt have full power. Today while mowing, it died another 5 or 6 times. A couple of times when the engine started to falter, I put tractor in neutral / turned off pto and the engine revved back up. Tonight I cleaned both fuel filters, then decided to see how much fuel the pump was actually pumping. It literally took 10 minutes to pump a quart of fuel. This was pulling thru the filters. Tomorrow I plan to bypass the filters and original fuel lines and run a temporary hose from pump into the tank and see how much fuel it will pump. Anyone know how many GPH this should be pumping? Any other suggestions to look for the problem??? 
|
|
#2
10-22-2016, 12:58 AM
|
||||
|
||||
|
Yes, pull the fuel cock and tank bung out and replace. While you are doing that, replace the supply and return line and you should be good for another 5 years.
__________________
This ain't no hobby....it's an addiction
|
|
#3
10-22-2016, 08:22 AM
|
||||
|
||||
|
I agree. Had the exact same problem on my 882D. Replaced fuel lines and bungs, and soaked the fittings in Super Clean from auto parts store. Good as new.
__________________
Don 882D 50" Deck Mower 54" Snow Dozer Blade Agri-Fab Lawn Sweep
|
|
#4
10-22-2016, 12:54 PM
|
||||
|
||||
|
Thanks guys... looks like I will start tearing into the fuel system this afternoon.
|
|
#5
10-22-2016, 01:07 PM
|
||||
|
||||
|
Make sure you remove the tank and clean it inside also. You'll be surprised at how much crud collects over the years.
__________________
2264 with 54 GT deck 1641 AKA Black Jack with a 402-E Haban Sickle bar mower JD317 dump truck BX2670 with FEL
|
|
#6
10-22-2016, 11:04 PM
|
||||
|
||||
|
You were spot on guys!
Took the fuel tank off, and found the pick up screen was pretty much plugged with crud. Cleaned the screen, cleaned out the tank, put all new fuel lines on, and new inline fuel filter. Put everything back together and once again she sings like new! Thanks!!!
|
|
#7
10-23-2016, 09:17 AM
|
||||
|
||||
|
I am glad you got it fixed. It nice when they run like new.
__________________
1572, 1864 x2, 1810 x2, 1863 & GT1554(Dad's Ole Mowers), 1811,782D, 1872 x2, 782DT(Sold), 3235, 1860, 1772 with 3-point and Turbo.
|
|
#9
10-24-2016, 09:04 AM
|
||||
|
||||
|
This past week on my 2182, I replaced all of the fuel lines, tank bushings (bungs), cleaned fuel tank, cleaned fuel shutoff valves, cleaned the whole rear end of tractor and it runs very smooth now. It was running a little rough on occasion but cleaning up the fuel system completely solved the problem! Am glad to hear that it worked for you as well.
|
|
#10
10-24-2016, 09:18 AM
|
|||
|
|||
|
Why is this such a common issue that takes so many by surprise and sometimes very hard to convince someone to do???
Thank you to the OP for doing what was suggested without questioning or arguing. So much of the time it takes us about 20 posts to convince someone that a dirty fuel system is the issue.
|
|
|
|
Cub Cadet is a premium line of outdoor power equipment, established in 1961 as part of International Harvester. During the 1960s, IH initiated an entirely new line of lawn and garden equipment aimed at the owners rural homes with large yards and private gardens. There were a wide variety of Cub Cadet branded and after-market attachments available; including mowers, blades, snow blowers, front loaders, plows, carts, etc. Cub Cadet advertising at that time harped on their thorough testing by "boys - acknowledged by many as the world's worst destructive force!". Cub Cadets became known for their dependability and rugged construction.
MTD Products, Inc. of Cleveland, Ohio purchased the Cub Cadet brand from International Harvester in 1981. Cub Cadet was held as a wholly owned subsidiary for many years following this acquisition, which allowed them to operate independently. Recently, MTD has taken a more aggressive role and integrated Cub Cadet into its other lines of power equipment.
This website and forum are not affiliated with or sponsored by MTD Products Inc, which owns the CUB CADET trademarks. It is not an official MTD Products Inc, website, and MTD Products Inc, is not responsible for any of its content. The official MTD Products Inc, website can be found at: http://www.mtdproducts.com. The information and opinions expressed on this website are the responsibility of the website's owner and/or it's members, and do not represent the opinions of MTD Products Inc. IH, INTERNATIONAL HARVESTER are registered trademark of CNH America LLC
All material, images, and graphics from this site are the property of www.onlycubcadets.net. Any unauthorized use, reproductions, or duplications are prohibited unless solely expressed in writing.
Cub Cadet, Cub, Cadet, IH, MTD, Parts, Tractors, Tractor, International Harvester, Lawn, Garden, Lawn Mower, Kohler, garden tractor equipment, lawn garden tractors, antique garden tractors, garden tractor, PTO, parts, online, Original, 70, 71, 72, 73, 76, SO76, 80, 81, 86, 100, 102, 104, 105, 106, 107, 108,109, 122, 123, 124, 125, 126, 127, 128, 129, 147, 149, 169, 182, 282, 382, 482, 580, 582, 582 Special, 680, 682, 782, 782D, 784, 800, 805, 882, 982, 984, 986, 1000, 1015, 1100, 1105, 1110, 1200, 1250, 1282, 1450, 1512, 1604, 1605, 1606, 1610, 1615, 1620, 1650, 1710, 1711, 1712, 1806, 1810, 1811, 1812, 1912, 1914.
Linear Mode
