|
PLEASE PATRONIZE OUR SPONSORS!
|
|||||||
 |
|
|
Thread Tools | Display Modes |
|
|
|
#1
10-16-2023, 11:41 AM
|
|||
|
|||
GT3200 wont turn off with new switch
My future father in law has a GT3200 that he loves and recently the key stopped working. I pulled the switch and opened it up to find some melted plastic and crud. Ordered a new Stens switch and it starts up fine, but will not shut off with the key now.
Was thinking the switch grounded the coil, but not finding a wire from the switch to the coil. Orange/white off "S" goes to the Brake switch which leads to an Orange/Black that leads to the PTO switch which leads to the orange/white to the solenoid. He has mentioned some issues with the PTO switch not engaging as well intermittently so this all may be tying together now. Thinking it may be a bad ignition switch I ordered a replacement. Any other ideas where to check? Hate to just start ordering a PTO switch as well as I don't want to just throw parts at it. Need to see if I can follow the wiring along from the brake switch to the pto and then to the solenoid... Wanted to check with others. Thanks! 
|
|
#2
10-16-2023, 12:59 PM
|
||||
|
||||
|
Assuming you have the correct switch, with the key in off position the magneto gets grounded thru contacts M and G.
Pull the plug off the switch and check to see if you have ground on the G contact of the plug. You might first check the 25 amp fuse that appears to provide the ground connection to the switch and also the PTO.
|
|
#3
10-16-2023, 01:26 PM
|
|||
|
|||
|
Thank you Ironman!!
Concentrating on the wiring too long I completely disregarded the key switch diagram at the bottom... Going to test this switch to see if it connects the 3 listed. Picked up a Stens Delta Ignition Switch 430-220 which crossed reference the same as the cub # and it has the same listed pinouts.
|
|
#4
10-16-2023, 01:48 PM
|
||||
|
||||
|
This is the ignition switch that is called out on the Cub parts site for a GT3200
925-06119C IGNITION MODULE SWITCH RMC (MAN PTO BLK) This part replaces 725-04227. Many times the "Will fit look a like's" are wired differently internally and they don't work.
__________________
2264 with 54 GT deck 1641 AKA Black Jack with a 402-E Haban Sickle bar mower JD317 dump truck BX2670 with FEL
|
|
#5
10-16-2023, 03:27 PM
|
|||
|
|||
|
I confirmed that the Stens switch is the same replacement..
https://www.stens.com/430-220-ignition-switch Also confirmed that is is not a switch issue as they are all connected when the switch is in the off position. So now for a lot of fun tracing wires.....
|
|
#7
10-16-2023, 05:00 PM
|
|||
|
|||
|
Quote:
|
|
|
|
Cub Cadet is a premium line of outdoor power equipment, established in 1961 as part of International Harvester. During the 1960s, IH initiated an entirely new line of lawn and garden equipment aimed at the owners rural homes with large yards and private gardens. There were a wide variety of Cub Cadet branded and after-market attachments available; including mowers, blades, snow blowers, front loaders, plows, carts, etc. Cub Cadet advertising at that time harped on their thorough testing by "boys - acknowledged by many as the world's worst destructive force!". Cub Cadets became known for their dependability and rugged construction.
MTD Products, Inc. of Cleveland, Ohio purchased the Cub Cadet brand from International Harvester in 1981. Cub Cadet was held as a wholly owned subsidiary for many years following this acquisition, which allowed them to operate independently. Recently, MTD has taken a more aggressive role and integrated Cub Cadet into its other lines of power equipment.
This website and forum are not affiliated with or sponsored by MTD Products Inc, which owns the CUB CADET trademarks. It is not an official MTD Products Inc, website, and MTD Products Inc, is not responsible for any of its content. The official MTD Products Inc, website can be found at: http://www.mtdproducts.com. The information and opinions expressed on this website are the responsibility of the website's owner and/or it's members, and do not represent the opinions of MTD Products Inc. IH, INTERNATIONAL HARVESTER are registered trademark of CNH America LLC
All material, images, and graphics from this site are the property of www.onlycubcadets.net. Any unauthorized use, reproductions, or duplications are prohibited unless solely expressed in writing.
Cub Cadet, Cub, Cadet, IH, MTD, Parts, Tractors, Tractor, International Harvester, Lawn, Garden, Lawn Mower, Kohler, garden tractor equipment, lawn garden tractors, antique garden tractors, garden tractor, PTO, parts, online, Original, 70, 71, 72, 73, 76, SO76, 80, 81, 86, 100, 102, 104, 105, 106, 107, 108,109, 122, 123, 124, 125, 126, 127, 128, 129, 147, 149, 169, 182, 282, 382, 482, 580, 582, 582 Special, 680, 682, 782, 782D, 784, 800, 805, 882, 982, 984, 986, 1000, 1015, 1100, 1105, 1110, 1200, 1250, 1282, 1450, 1512, 1604, 1605, 1606, 1610, 1615, 1620, 1650, 1710, 1711, 1712, 1806, 1810, 1811, 1812, 1912, 1914.
Hybrid Mode
