Choke plate jam - Only Cub Cadets

If you would like to help maintain this site & enhance it, feel free to donate whatever amount you would like to!

Attention Everyone, we have 2 new Sponsors!
Machtech Direct and P&K Cub Cadet (See Links above)

		Only Cub Cadets > Cub Cadets > Cub Cadet Engines
Choke plate jam

FAQ

Calendar

Thread Tools

Display Modes

02-14-2021, 03:47 PM

Mr Clean

New Member

Join Date: Feb 2015

Location: Maine

Posts: 4

Choke plate jam

Hello
Sorry I just posted this in the welcome forum, posting again in the engine forum. I have a 2166 that when I tighten the nuts on the fuel cup on the studs going through the carburetor on the air cleaner base it somehow causes the choke plate in the carb to jam, so it cant fully close. It stays about 2-4 mm it presses against the carb throat and sticks open just past the gasket and wont start. Its like it twists the carb. If I loosen up a bit on the nuts wham, she closes fine and Starts right up.
Its very puzzling, Ive tried pushing air cleaner base left, right up or down and tightening 1 nut at a time but when tight that darn choke wont close all the way. The studs are tight and all seems good. This is a brand new carb and I'm starting tot think this was the original problem I swapped the carb for! I'm hoping some one her has seen this and can offer a suggestion.

« Previous Thread | Next Thread »

Posting Rules
You may not post new threads You may not post replies You may not post attachments You may not edit your posts BB code is On Smilies are On [IMG] code is On HTML code is Off Forum Rules

Forum Jump

All times are GMT -4. The time now is 05:12 AM.

Cub Cadet is a premium line of outdoor power equipment, established in 1961 as part of International Harvester. During the 1960s, IH initiated an entirely new line of lawn and garden equipment aimed at the owners rural homes with large yards and private gardens. There were a wide variety of Cub Cadet branded and after-market attachments available; including mowers, blades, snow blowers, front loaders, plows, carts, etc. Cub Cadet advertising at that time harped on their thorough testing by "boys - acknowledged by many as the world's worst destructive force!". Cub Cadets became known for their dependability and rugged construction.

MTD Products, Inc. of Cleveland, Ohio purchased the Cub Cadet brand from International Harvester in 1981. Cub Cadet was held as a wholly owned subsidiary for many years following this acquisition, which allowed them to operate independently. Recently, MTD has taken a more aggressive role and integrated Cub Cadet into its other lines of power equipment.

This website and forum are not affiliated with or sponsored by MTD Products Inc, which owns the CUB CADET trademarks. It is not an official MTD Products Inc, website, and MTD Products Inc, is not responsible for any of its content. The official MTD Products Inc, website can be found at: http://www.mtdproducts.com. The information and opinions expressed on this website are the responsibility of the website's owner and/or it's members, and do not represent the opinions of MTD Products Inc. IH, INTERNATIONAL HARVESTER are registered trademark of CNH America LLC

All material, images, and graphics from this site are the property of www.onlycubcadets.net. Any unauthorized use, reproductions, or duplications are prohibited unless solely expressed in writing.

Cub Cadet, Cub, Cadet, IH, MTD, Parts, Tractors, Tractor, International Harvester, Lawn, Garden, Lawn Mower, Kohler, garden tractor equipment, lawn garden tractors, antique garden tractors, garden tractor, PTO, parts, online, Original, 70, 71, 72, 73, 76, SO76, 80, 81, 86, 100, 102, 104, 105, 106, 107, 108,109, 122, 123, 124, 125, 126, 127, 128, 129, 147, 149, 169, 182, 282, 382, 482, 580, 582, 582 Special, 680, 682, 782, 782D, 784, 800, 805, 882, 982, 984, 986, 1000, 1015, 1100, 1105, 1110, 1200, 1250, 1282, 1450, 1512, 1604, 1605, 1606, 1610, 1615, 1620, 1650, 1710, 1711, 1712, 1806, 1810, 1811, 1812, 1912, 1914.