|
PLEASE PATRONIZE OUR SPONSORS!
|
|||||||
 |
|
|
Thread Tools | Display Modes |
|
#1
11-04-2022, 07:59 PM
|
|||
|
|||
ECHO backpack blower carb replacement
Once again, I am on the receiving end of a FREE piece of equipment that has sat for many years. This time it's an ECHO PB-403T backpack blower from 2005.
I replaced the spark plug (due to no spark) and primer bulb (since it fell apart), and managed to get it to run. But the next day it won't fire up. I replaced the air and fuel filters, but still getting no fuel into the cylinder. So I guess some sediments or something got sucked from the tank and gummed up the carb. I ordered a new OEM carb and gaskets, is there anything special I need to do as far as high/low adjustments? Or do these OEM carbs come ready to go from the factory? 
|
|
#2
11-10-2022, 02:23 PM
|
|||
|
|||
|
If it’s adjustable at there’s special tools. The screws have odd ball heads on them.
__________________
Doug Dad's 122 w/42" cast deck, spring assist, lights,weights, rear lift 1250 w/hydraulic lift, lights,weights, spring assist. 50C deck converted to an A with front wheels 44C deck converted to an A with front wheels. QA-36A 42" blade
|
|
#3
11-10-2022, 05:13 PM
|
||||
|
||||
|
I would check the service book, often 2 cycle stuff now comes somewhat adjusted and "capped". You can remove those caps and use the aforementioned screwdrivers to dial it in.
https://www.farmandfleet.com/product...waAlWxEALw_wcB
__________________
Why Farm Half When You Can Farmall? 1282 | 44C Deck, Chains, 42" Blade, Cast Weights, 020" Over K301 * 1711 | 50C Deck, #1 Rear Rototiller w/ Extensions, Sleeve Hitch, KT17S Series II 24302 --> CH18S * 1811 | 46 GT Deck, 42" Blade, Chains, M18 Magnum, Sleeve Hitch * 1782 | 60" #375 Deck, Kubota D640 Diesel * 1862 | #450 Snowblower, M18 Magnum * 782 | Y/W KT17 Series II, Sleeve Hitch * 984 | Y/W Onan/Linamar 20HP, Sims Cab, CAT 0 3 PT w/ Rear PTO, 60" #374 Deck
|
|
#4
11-12-2022, 01:05 PM
|
||||
|
||||
|
Be sure you have the correct mix, spark plug and such.
https://www.echo-usa.com/getattachme...1c2873/filev1_
__________________
Up to 530 and counting... I give up updating my profile!
|
|
#5
11-13-2022, 08:30 AM
|
|||
|
|||
|
I used an official echo tune up kit with the air filter, spark plug, and fuel filter. Spark plug gap is .65 as the manual states. Fuel is 50:1 mix as manual states.
Even with the brand new carb it runs rough, won't idle half the time, or hesitates a lot. The new one came with limiter caps in the box but not installed, so I assume it needs adjustments and put those one once it's set? But I have idea where to start with the adjustments...
|
|
#6
11-14-2022, 10:33 AM
|
||||
|
||||
|
I'm not familiar with Echo's but other brands have problems with the exhaust clogging up.
Remove the muffler and you may find a fine mesh screen, inside the muffler or on the input. That screen can clog or there may be excessive carbon inside the muffler. Worth a looksee.
|
|
#7
11-16-2022, 09:17 PM
|
|||
|
|||
|
I will try and clean the spark arrestor screen this weekend. If still not running right, I found a local shop that said they will only charge $25 to tune the carb. They said they can do it while I wait, not even 15 mins provided nothing else is wrong. I don't foresee anything else being wrong, as I've literally done all user serviceable parts at that point!
|
|
#8
11-19-2022, 11:49 AM
|
|||
|
|||
|
Well I couldn't get the muffler off to clean the spark arrestor (too rusty). But I found the problem. When I initially installed the carb I had to reuse one of the old gaskets due to the one it came with being damaged. I replaced it just now with a new one and it fired right up no issues! No hesitation or anything it just runs and blows fine
|
|
|
|
Cub Cadet is a premium line of outdoor power equipment, established in 1961 as part of International Harvester. During the 1960s, IH initiated an entirely new line of lawn and garden equipment aimed at the owners rural homes with large yards and private gardens. There were a wide variety of Cub Cadet branded and after-market attachments available; including mowers, blades, snow blowers, front loaders, plows, carts, etc. Cub Cadet advertising at that time harped on their thorough testing by "boys - acknowledged by many as the world's worst destructive force!". Cub Cadets became known for their dependability and rugged construction.
MTD Products, Inc. of Cleveland, Ohio purchased the Cub Cadet brand from International Harvester in 1981. Cub Cadet was held as a wholly owned subsidiary for many years following this acquisition, which allowed them to operate independently. Recently, MTD has taken a more aggressive role and integrated Cub Cadet into its other lines of power equipment.
This website and forum are not affiliated with or sponsored by MTD Products Inc, which owns the CUB CADET trademarks. It is not an official MTD Products Inc, website, and MTD Products Inc, is not responsible for any of its content. The official MTD Products Inc, website can be found at: http://www.mtdproducts.com. The information and opinions expressed on this website are the responsibility of the website's owner and/or it's members, and do not represent the opinions of MTD Products Inc. IH, INTERNATIONAL HARVESTER are registered trademark of CNH America LLC
All material, images, and graphics from this site are the property of www.onlycubcadets.net. Any unauthorized use, reproductions, or duplications are prohibited unless solely expressed in writing.
Cub Cadet, Cub, Cadet, IH, MTD, Parts, Tractors, Tractor, International Harvester, Lawn, Garden, Lawn Mower, Kohler, garden tractor equipment, lawn garden tractors, antique garden tractors, garden tractor, PTO, parts, online, Original, 70, 71, 72, 73, 76, SO76, 80, 81, 86, 100, 102, 104, 105, 106, 107, 108,109, 122, 123, 124, 125, 126, 127, 128, 129, 147, 149, 169, 182, 282, 382, 482, 580, 582, 582 Special, 680, 682, 782, 782D, 784, 800, 805, 882, 982, 984, 986, 1000, 1015, 1100, 1105, 1110, 1200, 1250, 1282, 1450, 1512, 1604, 1605, 1606, 1610, 1615, 1620, 1650, 1710, 1711, 1712, 1806, 1810, 1811, 1812, 1912, 1914.
Linear Mode
