PLEASE PATRONIZE OUR SPONSORS!
|
|
Thread Tools | Display Modes |
#1
|
||||
|
||||
782 rough start/won't run
782 with a series I, always ran great. End of mowing season began to run rough. Just replaced carburetor with a new one. Earlier in the season replaced entire ignition system due to no spark. It will smoke some, spit and die now, won’t stay running, thinking it must be the valves? It has a new fuel filter, fuel line and good battery.
Took fuel line off carb to verify fuel pump, works well. Reinstalled. Will start and run at idle, still not great but very poorly at full throttle, backfires and misses.
__________________
-Rick IH 782 IH 126 CCC 1863 |
#2
|
||||
|
||||
Maybe threw a rod? check to see...
__________________
Up to 530 and counting... I give up updating my profile! |
#3
|
||||
|
||||
Did the compression test OK?
__________________
Why Farm Half When You Can Farmall? 1282 | 44C Deck, Chains, 42" Blade, Cast Weights, 020" Over K301 * 1711 | 50C Deck, #1 Rear Rototiller w/ Extensions, Sleeve Hitch, KT17S Series II 24302 --> CH18S * 1811 | 46 GT Deck, 42" Blade, Chains, M18 Magnum, Sleeve Hitch * 1782 | 60" #375 Deck, Kubota D640 Diesel * 1862 | #450 Snowblower, M18 Magnum * 782 | Y/W KT17 Series II, Sleeve Hitch * 984 | Y/W Onan/Linamar 20HP, Sims Cab, CAT 0 3 PT w/ Rear PTO, 60" #374 Deck |
#4
|
||||
|
||||
Compression shows a little above 80 on both sides. I pulled the heads, a lot of carbon buildup. Going to get everything cleaned up and heads resurfaced for when the new gaskets get in
__________________
-Rick IH 782 IH 126 CCC 1863 |
#5
|
||||
|
||||
If you used a China replacement carb, it might cause issues. I would rebuild your old one and see if anything improves.
__________________
582, 682, 782, 782D, 1282, 1050, 1210 x 2, 1711, and 1811 |
#6
|
|||
|
|||
Quote:
__________________
[B]Roland Bedell[/B] CC Models: 100, 105, 1450, 782, (2) 784, & 2072 [SIZE="4"][B][COLOR="Red"]Buy:[/COLOR][COLOR="Blue"] Made in the USA[/COLOR][/B] [/SIZE]:American Flag 1: |
#7
|
||||
|
||||
Replaced existing original carburetor with a new carburetor from isavetractors. It’s a quality product. I’ve rebuilt the oem carb too many times to count over the years, figured I’d get a new one. I’m hoping new head gaskets and removing the carbon build up gets it running smoothly again.
__________________
-Rick IH 782 IH 126 CCC 1863 |
|
|
Cub Cadet is a premium line of outdoor power equipment, established in 1961 as part of International Harvester. During the 1960s, IH initiated an entirely new line of lawn and garden equipment aimed at the owners rural homes with large yards and private gardens. There were a wide variety of Cub Cadet branded and after-market attachments available; including mowers, blades, snow blowers, front loaders, plows, carts, etc. Cub Cadet advertising at that time harped on their thorough testing by "boys - acknowledged by many as the world's worst destructive force!". Cub Cadets became known for their dependability and rugged construction.
MTD Products, Inc. of Cleveland, Ohio purchased the Cub Cadet brand from International Harvester in 1981. Cub Cadet was held as a wholly owned subsidiary for many years following this acquisition, which allowed them to operate independently. Recently, MTD has taken a more aggressive role and integrated Cub Cadet into its other lines of power equipment.
This website and forum are not affiliated with or sponsored by MTD Products Inc, which owns the CUB CADET trademarks. It is not an official MTD Products Inc, website, and MTD Products Inc, is not responsible for any of its content. The official MTD Products Inc, website can be found at: http://www.mtdproducts.com. The information and opinions expressed on this website are the responsibility of the website's owner and/or it's members, and do not represent the opinions of MTD Products Inc. IH, INTERNATIONAL HARVESTER are registered trademark of CNH America LLC
All material, images, and graphics from this site are the property of www.onlycubcadets.net. Any unauthorized use, reproductions, or duplications are prohibited unless solely expressed in writing.
Cub Cadet, Cub, Cadet, IH, MTD, Parts, Tractors, Tractor, International Harvester, Lawn, Garden, Lawn Mower, Kohler, garden tractor equipment, lawn garden tractors, antique garden tractors, garden tractor, PTO, parts, online, Original, 70, 71, 72, 73, 76, SO76, 80, 81, 86, 100, 102, 104, 105, 106, 107, 108,109, 122, 123, 124, 125, 126, 127, 128, 129, 147, 149, 169, 182, 282, 382, 482, 580, 582, 582 Special, 680, 682, 782, 782D, 784, 800, 805, 882, 982, 984, 986, 1000, 1015, 1100, 1105, 1110, 1200, 1250, 1282, 1450, 1512, 1604, 1605, 1606, 1610, 1615, 1620, 1650, 1710, 1711, 1712, 1806, 1810, 1811, 1812, 1912, 1914.