|
PLEASE PATRONIZE OUR SPONSORS!
|
|||||||
 |
|
|
Thread Tools | Display Modes |
|
#1
05-26-2024, 11:43 AM
|
|||
|
|||
D600 Operating Temperature
My 782d seems to be running hot to the touch. What temperature should the engine be running at? I run the engine about 30 minutes and the oil cap is so hot to touch. Is this normal? If not, what should I be looking at diagnosing?
|
|
#2
05-26-2024, 12:55 PM
|
||||
|
||||
|
Does the gauge still work? Is the insulation still on the top hose that goes to the radiator?
It is going to get pretty hot under the hood.
__________________
1572, 1864 x2, 1810 x2, 1863 & GT1554(Dad's Ole Mowers), 1811,782D, 1872 x2, 782DT(Sold), 3235, 1860, 1772 with 3-point and Turbo.
|
|
#4
05-26-2024, 01:08 PM
|
||||
|
||||
|
I am going to cut the grass with m 1572 this afternoon. I will take some pictures of the gauge after 30 minutes of run time. Good comparison test.
__________________
1572, 1864 x2, 1810 x2, 1863 & GT1554(Dad's Ole Mowers), 1811,782D, 1872 x2, 782DT(Sold), 3235, 1860, 1772 with 3-point and Turbo.
|
|
#5
05-27-2024, 09:22 AM
|
||||
|
||||
|
What is your gauge reading? I think anything over 140* will feel hot to the touch. Here's what the decal says under the hood. " Anything under 230* is normal". I don't think mine ever get above 170*.
DSC02997.jpg
__________________
This ain't no hobby....it's an addiction
|
|
#6
05-27-2024, 02:38 PM
|
||||
|
||||
|
This is after 10 minutes of run time.
__________________
1572, 1864 x2, 1810 x2, 1863 & GT1554(Dad's Ole Mowers), 1811,782D, 1872 x2, 782DT(Sold), 3235, 1860, 1772 with 3-point and Turbo.
|
|
#7
05-27-2024, 02:42 PM
|
||||
|
||||
|
After 30 minutes of working the mower pretty good. I stopped to see how hot the oil cap was and you could hold it 2-3 seconds. I let it run for a couple of minutes with no load and it cooled down fast. I mowed a little slower in the tall grass and it did not get as hot.
__________________
1572, 1864 x2, 1810 x2, 1863 & GT1554(Dad's Ole Mowers), 1811,782D, 1872 x2, 782DT(Sold), 3235, 1860, 1772 with 3-point and Turbo.
|
|
#8
05-27-2024, 02:45 PM
|
||||
|
||||
|
I do this to all my diesels and it helps. The crossover hose will pick up heat from the engine. Might be overkill but only takes a few minutes to do.
__________________
1572, 1864 x2, 1810 x2, 1863 & GT1554(Dad's Ole Mowers), 1811,782D, 1872 x2, 782DT(Sold), 3235, 1860, 1772 with 3-point and Turbo.
|
|
#9
05-30-2024, 11:13 AM
|
||||
|
||||
My 782D has a 180 degree thermostat. It has all new coolant and belts. It likes to run 190 degrees on hot days while mowing. The OE gauge has been replaced with a mechanical numerical gauge for better temperature accuracy.
__________________
 582, 682, 782, 782D, 1282, 1050, 1210 x 2, 1711, and 1811
|
|
|
|
Cub Cadet is a premium line of outdoor power equipment, established in 1961 as part of International Harvester. During the 1960s, IH initiated an entirely new line of lawn and garden equipment aimed at the owners rural homes with large yards and private gardens. There were a wide variety of Cub Cadet branded and after-market attachments available; including mowers, blades, snow blowers, front loaders, plows, carts, etc. Cub Cadet advertising at that time harped on their thorough testing by "boys - acknowledged by many as the world's worst destructive force!". Cub Cadets became known for their dependability and rugged construction.
MTD Products, Inc. of Cleveland, Ohio purchased the Cub Cadet brand from International Harvester in 1981. Cub Cadet was held as a wholly owned subsidiary for many years following this acquisition, which allowed them to operate independently. Recently, MTD has taken a more aggressive role and integrated Cub Cadet into its other lines of power equipment.
This website and forum are not affiliated with or sponsored by MTD Products Inc, which owns the CUB CADET trademarks. It is not an official MTD Products Inc, website, and MTD Products Inc, is not responsible for any of its content. The official MTD Products Inc, website can be found at: http://www.mtdproducts.com. The information and opinions expressed on this website are the responsibility of the website's owner and/or it's members, and do not represent the opinions of MTD Products Inc. IH, INTERNATIONAL HARVESTER are registered trademark of CNH America LLC
All material, images, and graphics from this site are the property of www.onlycubcadets.net. Any unauthorized use, reproductions, or duplications are prohibited unless solely expressed in writing.
Cub Cadet, Cub, Cadet, IH, MTD, Parts, Tractors, Tractor, International Harvester, Lawn, Garden, Lawn Mower, Kohler, garden tractor equipment, lawn garden tractors, antique garden tractors, garden tractor, PTO, parts, online, Original, 70, 71, 72, 73, 76, SO76, 80, 81, 86, 100, 102, 104, 105, 106, 107, 108,109, 122, 123, 124, 125, 126, 127, 128, 129, 147, 149, 169, 182, 282, 382, 482, 580, 582, 582 Special, 680, 682, 782, 782D, 784, 800, 805, 882, 982, 984, 986, 1000, 1015, 1100, 1105, 1110, 1200, 1250, 1282, 1450, 1512, 1604, 1605, 1606, 1610, 1615, 1620, 1650, 1710, 1711, 1712, 1806, 1810, 1811, 1812, 1912, 1914.
Linear Mode
