|
PLEASE PATRONIZE OUR SPONSORS!
|
|||||||
 |
|
|
Thread Tools | Display Modes |
|
#1
10-20-2024, 09:16 PM
|
||||
|
||||
Kohler CH18 enging running rough
My 1864 has been acting up lately...lacking power. I checked both spark plugs (just put in new autolite plugs) two weeks ago, changed oil to get ready for leaf season etc.
Today, I tried starting the engine with the right plug wire pulled. It seemed to run ok, but not normal at low idle. Then, I pulled the left plug wire, (reconnecting the right) and tried to start it again. No such luck. No start. I'm guessing that the ignition coil for the right cylinder is the problem. Is it possible that the coil is open. The engine seemed to be running hotter than usual the last time I mowed. Could that have caused the problem? Any recommendations on where to order coils from? (if that is the problem) Help is appreciated! 
|
|
#3
10-25-2024, 10:41 AM
|
||||
|
||||
|
CH18
Checked for spark...good. Checked for stuck valve...good. Compression test...good. Checked conductivity of spark plugs...NOT GOOD!
I installed 2 Autolite plugs a few weeks ago. They worked the next time I cut the lawn. Did not work the last time. I have had trouble in the past with non-conductive Autolite brand (from Walmart) plugs..seems I haven't learned my lesson about using cheap plugs. The apparent problem is that the top of the plug is "non-conductive" where the boot wire attaches. Tested with a continuity tester to determine this. Removed coating with a wire wheel and reconnected. Started right up, smooth idle and plenty of power at high RPM. So I got things workin' but I want to find a better quality set of plugs that will do the job. I believe the originals were Champion RC12YC which may not be the best for the engine. Does anyone have a solid performer that will make the engine run well? Anything from NGK or other brands? Your thoughts are very much appreciated!! 
|
|
#4
10-29-2024, 01:35 AM
|
||||
|
||||
|
I use Champion 2071 but they are no longer available , i bought a few and they will see me out
Great plugs Go to a cross-reference site for plugs Check online you may still find some 2071 heres one a bit dear https://www.ebay.com.au/itm/15595772...Bk9SR7j4kezaZA Oz
__________________
My wife says I do not listen , at least I think thats what she said
|
|
#6
10-29-2024, 11:11 AM
|
||||
|
||||
|
CH18
Thanks for the replies...Going to try some NGK BCPR5ES (6130) plugs that cross reference with Champion RC12YC. My Autolite plugs are working since I cleaned off the tops where the boots connect, however I'm going to change them out for the NGK's to see if I get better results...
|
|
|
|
Cub Cadet is a premium line of outdoor power equipment, established in 1961 as part of International Harvester. During the 1960s, IH initiated an entirely new line of lawn and garden equipment aimed at the owners rural homes with large yards and private gardens. There were a wide variety of Cub Cadet branded and after-market attachments available; including mowers, blades, snow blowers, front loaders, plows, carts, etc. Cub Cadet advertising at that time harped on their thorough testing by "boys - acknowledged by many as the world's worst destructive force!". Cub Cadets became known for their dependability and rugged construction.
MTD Products, Inc. of Cleveland, Ohio purchased the Cub Cadet brand from International Harvester in 1981. Cub Cadet was held as a wholly owned subsidiary for many years following this acquisition, which allowed them to operate independently. Recently, MTD has taken a more aggressive role and integrated Cub Cadet into its other lines of power equipment.
This website and forum are not affiliated with or sponsored by MTD Products Inc, which owns the CUB CADET trademarks. It is not an official MTD Products Inc, website, and MTD Products Inc, is not responsible for any of its content. The official MTD Products Inc, website can be found at: http://www.mtdproducts.com. The information and opinions expressed on this website are the responsibility of the website's owner and/or it's members, and do not represent the opinions of MTD Products Inc. IH, INTERNATIONAL HARVESTER are registered trademark of CNH America LLC
All material, images, and graphics from this site are the property of www.onlycubcadets.net. Any unauthorized use, reproductions, or duplications are prohibited unless solely expressed in writing.
Cub Cadet, Cub, Cadet, IH, MTD, Parts, Tractors, Tractor, International Harvester, Lawn, Garden, Lawn Mower, Kohler, garden tractor equipment, lawn garden tractors, antique garden tractors, garden tractor, PTO, parts, online, Original, 70, 71, 72, 73, 76, SO76, 80, 81, 86, 100, 102, 104, 105, 106, 107, 108,109, 122, 123, 124, 125, 126, 127, 128, 129, 147, 149, 169, 182, 282, 382, 482, 580, 582, 582 Special, 680, 682, 782, 782D, 784, 800, 805, 882, 982, 984, 986, 1000, 1015, 1100, 1105, 1110, 1200, 1250, 1282, 1450, 1512, 1604, 1605, 1606, 1610, 1615, 1620, 1650, 1710, 1711, 1712, 1806, 1810, 1811, 1812, 1912, 1914.
Linear Mode
