PLEASE PATRONIZE OUR SPONSORS!
|
|
Thread Tools | Display Modes |
#21
|
||||
|
||||
Next in the pics of this project.
1st is the seal with the snap ring 2nd is the seal and snap ring removed 3rd is the seal, snap ring, bearings and the C-clips
__________________
2264 with 54 GT deck 1641 AKA Black Jack with a 402-E Haban Sickle bar mower JD317 dump truck BX2670 with FEL |
#22
|
||||
|
||||
Some of the tools used on this job
1st pic snap ring pliers, seal puller & scrapers 2nd pic Vacuum pump to suck the crud out of the axle tubes 3rd pic crud that was in the axle tubes 4th pic screw drivers used to pop the C-clips off the ends of the axles 5th pic new rear cover from Xtreme 6th pic GT braces from Xtreme I will use OEM seals on this one, I have used National seals on one other Cyclops and they leaked around the outside of the seal so I ended up having to do the job over, I was not a happy camper. The OEM seal part number is 921-3020A SEAL-OIL this is the Cub Price $6.85 you need 2 of these This is the rear cover gasket, some people just use RTV choice is up to you 921-3015 GASKET Cub Price $8.57
__________________
2264 with 54 GT deck 1641 AKA Black Jack with a 402-E Haban Sickle bar mower JD317 dump truck BX2670 with FEL |
#23
|
|||
|
|||
Awesome pictorial - I'll let you know if I run into any additional (shouldn't try this at home) issues.
|
#24
|
||||
|
||||
Worked on the 1864/2264 for about 2 hours today got it almost all back together. Hope to finish it tomorrow.
__________________
2264 with 54 GT deck 1641 AKA Black Jack with a 402-E Haban Sickle bar mower JD317 dump truck BX2670 with FEL |
#25
|
|||
|
|||
Quote:
Untested, as I've got to make a trip to town for tranny fluid. I'm so confident in my (er-uh)driveway mechanical abilities ..... bought a 2084, relegating the 1882 to back-up status. |
#26
|
||||
|
||||
Got my toy done yesterday http://www.onlycubcadets.net/forum/s...=46990&page=11
Post your results when you get a chance.
__________________
2264 with 54 GT deck 1641 AKA Black Jack with a 402-E Haban Sickle bar mower JD317 dump truck BX2670 with FEL |
#27
|
|||
|
|||
Well, it ran down the driveway ..... and back (giddy up).
Haven't put the blower (or blade) on it yet. It has needed to be "primed" each time I've started it since the "electrical LOL issue" Its been suggested I have the fuel pump hooked up wrong. Go Figure. |
#28
|
|||
|
|||
If you do, it wouldn't run at all. Pretty sure you don't if it will run.
|
#29
|
||||
|
||||
1882 should have a vacuum operated fuel pump. Did you replace it with an electric pump? If so post some pics.
__________________
2264 with 54 GT deck 1641 AKA Black Jack with a 402-E Haban Sickle bar mower JD317 dump truck BX2670 with FEL |
#30
|
|||
|
|||
The early[1990] Cyclops still used the engine mounted fuel pumps.
|
|
|
Cub Cadet is a premium line of outdoor power equipment, established in 1961 as part of International Harvester. During the 1960s, IH initiated an entirely new line of lawn and garden equipment aimed at the owners rural homes with large yards and private gardens. There were a wide variety of Cub Cadet branded and after-market attachments available; including mowers, blades, snow blowers, front loaders, plows, carts, etc. Cub Cadet advertising at that time harped on their thorough testing by "boys - acknowledged by many as the world's worst destructive force!". Cub Cadets became known for their dependability and rugged construction.
MTD Products, Inc. of Cleveland, Ohio purchased the Cub Cadet brand from International Harvester in 1981. Cub Cadet was held as a wholly owned subsidiary for many years following this acquisition, which allowed them to operate independently. Recently, MTD has taken a more aggressive role and integrated Cub Cadet into its other lines of power equipment.
This website and forum are not affiliated with or sponsored by MTD Products Inc, which owns the CUB CADET trademarks. It is not an official MTD Products Inc, website, and MTD Products Inc, is not responsible for any of its content. The official MTD Products Inc, website can be found at: http://www.mtdproducts.com. The information and opinions expressed on this website are the responsibility of the website's owner and/or it's members, and do not represent the opinions of MTD Products Inc. IH, INTERNATIONAL HARVESTER are registered trademark of CNH America LLC
All material, images, and graphics from this site are the property of www.onlycubcadets.net. Any unauthorized use, reproductions, or duplications are prohibited unless solely expressed in writing.
Cub Cadet, Cub, Cadet, IH, MTD, Parts, Tractors, Tractor, International Harvester, Lawn, Garden, Lawn Mower, Kohler, garden tractor equipment, lawn garden tractors, antique garden tractors, garden tractor, PTO, parts, online, Original, 70, 71, 72, 73, 76, SO76, 80, 81, 86, 100, 102, 104, 105, 106, 107, 108,109, 122, 123, 124, 125, 126, 127, 128, 129, 147, 149, 169, 182, 282, 382, 482, 580, 582, 582 Special, 680, 682, 782, 782D, 784, 800, 805, 882, 982, 984, 986, 1000, 1015, 1100, 1105, 1110, 1200, 1250, 1282, 1450, 1512, 1604, 1605, 1606, 1610, 1615, 1620, 1650, 1710, 1711, 1712, 1806, 1810, 1811, 1812, 1912, 1914.