PLEASE PATRONIZE OUR SPONSORS!
|
|
Thread Tools | Display Modes |
#1
|
||||
|
||||
1863 deck belt pulley
I was able to mow a few minutes with the 1863 this morning though most of my grass is dead. I believe I have found the problem the PO had tearing up belts. The left belt pulley has a dent in it (in picture) and is not in line with the PTO or the deck pulley. The arm that holds the pulley seams to be bent allowing the pulley to be a little pigeon towed to the belt and frame. Should I attempt to straighten the pulley and bend the arm that holds it?
Cannon |
#2
|
||||
|
||||
Either replace the pulley or try to bend it back, but don't bend the arms...as you can see in the second picture, it's perfectly in line with the deck, so leave it alone. That's the way it came from the factory.
|
#3
|
|||
|
|||
I second trying to straighten the pulley, not the shaft. The deck on my 1862 had a similar bend in a pulley, it was slightly deeper but didn't extend around the pulley as far as yours. I was able to get it pretty close with some vice grips and a little tapping with a hammer and a backing block. If you make any rough spots on the tapered portion of the pulley during the straightening process do your best to get them as smooth as possible, usually a little file work and some fine sandpaper will do the trick.
|
#4
|
|||
|
|||
I think the best thing to do is spend $20 and replace the pulley. There is a good chance that the bearing is shot on the one you have.
|
#5
|
||||
|
||||
I straightened the pulley and mowed about 20 minutes, It seemed to work fine. Thanks
Cannon |
|
|
Cub Cadet is a premium line of outdoor power equipment, established in 1961 as part of International Harvester. During the 1960s, IH initiated an entirely new line of lawn and garden equipment aimed at the owners rural homes with large yards and private gardens. There were a wide variety of Cub Cadet branded and after-market attachments available; including mowers, blades, snow blowers, front loaders, plows, carts, etc. Cub Cadet advertising at that time harped on their thorough testing by "boys - acknowledged by many as the world's worst destructive force!". Cub Cadets became known for their dependability and rugged construction.
MTD Products, Inc. of Cleveland, Ohio purchased the Cub Cadet brand from International Harvester in 1981. Cub Cadet was held as a wholly owned subsidiary for many years following this acquisition, which allowed them to operate independently. Recently, MTD has taken a more aggressive role and integrated Cub Cadet into its other lines of power equipment.
This website and forum are not affiliated with or sponsored by MTD Products Inc, which owns the CUB CADET trademarks. It is not an official MTD Products Inc, website, and MTD Products Inc, is not responsible for any of its content. The official MTD Products Inc, website can be found at: http://www.mtdproducts.com. The information and opinions expressed on this website are the responsibility of the website's owner and/or it's members, and do not represent the opinions of MTD Products Inc. IH, INTERNATIONAL HARVESTER are registered trademark of CNH America LLC
All material, images, and graphics from this site are the property of www.onlycubcadets.net. Any unauthorized use, reproductions, or duplications are prohibited unless solely expressed in writing.
Cub Cadet, Cub, Cadet, IH, MTD, Parts, Tractors, Tractor, International Harvester, Lawn, Garden, Lawn Mower, Kohler, garden tractor equipment, lawn garden tractors, antique garden tractors, garden tractor, PTO, parts, online, Original, 70, 71, 72, 73, 76, SO76, 80, 81, 86, 100, 102, 104, 105, 106, 107, 108,109, 122, 123, 124, 125, 126, 127, 128, 129, 147, 149, 169, 182, 282, 382, 482, 580, 582, 582 Special, 680, 682, 782, 782D, 784, 800, 805, 882, 982, 984, 986, 1000, 1015, 1100, 1105, 1110, 1200, 1250, 1282, 1450, 1512, 1604, 1605, 1606, 1610, 1615, 1620, 1650, 1710, 1711, 1712, 1806, 1810, 1811, 1812, 1912, 1914.