PLEASE PATRONIZE OUR SPONSORS!
|
|
Thread Tools | Display Modes |
#1
|
||||
|
||||
n00b Question - Front Wheel Alignment - Pic Inside
I have a bit of a n00b question. I'm no stranger to mechanical work and have done all kind of repairs, I'm just wondering about the front wheel alignment on my 2018 XT2, although my 2009 Craftsman tractor has the same issue: The front wheels don't want to aim the same direction. When you get one wheel pointed straight, the opposite wheel points outboard for some reason. Luckily the issue hasn't been too serious as I'm just in the forgiving soft grass but hey! I want to get this corrected.
On the Craftsman I could find no adjustment to correct this so I thought one of the tie rods must be bent...so I replaced both of the tie rods with brand new ones and this had no effect on the issue. The only sure way I can see out of this is to remove one of the tie rods, heat it up and bend it slightly? Now I've noticed that my much newer XT2 has the same problem. It's in the shed for the winter and I haven't had a chance to look underneath it to see if it's the same steering design. Is there an easy fix for these that I'm overlooking? Here's a pic of my XT2 (and my old gray Craftsman poking its nose out there on the right side):
__________________
2011 Cub Cadet Volunteer 2011 Cub Cadet Z-Force Commercial 2018 Cub Cadet XT2 Lawn Tractor 1994 Cub Cadet 524 Snowblower |
#2
|
||||
|
||||
Are the tie rod ends threaded onto the rods so you can adjust them like you would on your vehicles?
If so, just set the toe in about 1/8" closer in the front than in the rear using your tape measurer. Its pretty simple to do as it is the only setting you can make. The caster and camber is not adjustable like on a vehicle. |
#3
|
|||
|
|||
I agree with George, but you will find some helpful information in this video as well:
https://www.youtube.com/watch?v=zb2kxlYukw8 |
#4
|
||||
|
||||
And another....
https://www.youtube.com/watch?v=XV_z5jKj-zI |
#5
|
||||
|
||||
Ok. Upon a further inspection this afternoon, I went out to the shed and confirmed that the tie rods on my Cub Cadet XT2 do in fact have threaded ends which allow for adjustment.
By contrast, the tie rods on my Craftsman rider sitting in the same shed, have no adjustment at all. I wonder why they would design it in such a stupid way with no recourse to align the front wheels. Thanks for the input!
__________________
2011 Cub Cadet Volunteer 2011 Cub Cadet Z-Force Commercial 2018 Cub Cadet XT2 Lawn Tractor 1994 Cub Cadet 524 Snowblower |
#6
|
|||
|
|||
Quote:
Serviceability, adjustability, maintainability, are all aftermarket concerns and not the manufacturers problem. |
|
|
Cub Cadet is a premium line of outdoor power equipment, established in 1961 as part of International Harvester. During the 1960s, IH initiated an entirely new line of lawn and garden equipment aimed at the owners rural homes with large yards and private gardens. There were a wide variety of Cub Cadet branded and after-market attachments available; including mowers, blades, snow blowers, front loaders, plows, carts, etc. Cub Cadet advertising at that time harped on their thorough testing by "boys - acknowledged by many as the world's worst destructive force!". Cub Cadets became known for their dependability and rugged construction.
MTD Products, Inc. of Cleveland, Ohio purchased the Cub Cadet brand from International Harvester in 1981. Cub Cadet was held as a wholly owned subsidiary for many years following this acquisition, which allowed them to operate independently. Recently, MTD has taken a more aggressive role and integrated Cub Cadet into its other lines of power equipment.
This website and forum are not affiliated with or sponsored by MTD Products Inc, which owns the CUB CADET trademarks. It is not an official MTD Products Inc, website, and MTD Products Inc, is not responsible for any of its content. The official MTD Products Inc, website can be found at: http://www.mtdproducts.com. The information and opinions expressed on this website are the responsibility of the website's owner and/or it's members, and do not represent the opinions of MTD Products Inc. IH, INTERNATIONAL HARVESTER are registered trademark of CNH America LLC
All material, images, and graphics from this site are the property of www.onlycubcadets.net. Any unauthorized use, reproductions, or duplications are prohibited unless solely expressed in writing.
Cub Cadet, Cub, Cadet, IH, MTD, Parts, Tractors, Tractor, International Harvester, Lawn, Garden, Lawn Mower, Kohler, garden tractor equipment, lawn garden tractors, antique garden tractors, garden tractor, PTO, parts, online, Original, 70, 71, 72, 73, 76, SO76, 80, 81, 86, 100, 102, 104, 105, 106, 107, 108,109, 122, 123, 124, 125, 126, 127, 128, 129, 147, 149, 169, 182, 282, 382, 482, 580, 582, 582 Special, 680, 682, 782, 782D, 784, 800, 805, 882, 982, 984, 986, 1000, 1015, 1100, 1105, 1110, 1200, 1250, 1282, 1450, 1512, 1604, 1605, 1606, 1610, 1615, 1620, 1650, 1710, 1711, 1712, 1806, 1810, 1811, 1812, 1912, 1914.