|
PLEASE PATRONIZE OUR SPONSORS!
|
|||||||
 |
|
|
Thread Tools | Display Modes |
|
#1
04-13-2024, 11:51 PM
|
|||
|
|||
D600 starting issues
I’m working on trying to get my diesel Cub to start with no success. It acts like it wants to run for about 5 seconds and puffs white smoke and dies. Any suggestions in what to look for is greatly appreciated.
I have fuel to the injectors. Being white smoke, it would lead me to believe it is a head gasket issue, but there isn’t any water in the oil. 
|
|
#2
04-14-2024, 07:31 AM
|
||||
|
||||
|
Are you sure your glow plugs are working and how long are you energizing them before you try to start it?
You may need to do a compression test. Have you adjusted the valves? Have you done the diesel upgrades yet? They make a huge difference in starting them. Gear reduction starter https://www.onlycubcadets.net/forum/showthread.php?t=1 Glow plug upgrade Get (3) NGK 2031 (Y-103V) and rewire them using a solenoid. Lots of posts on OCC doing that.
__________________
This ain't no hobby....it's an addiction
|
|
#3
04-14-2024, 09:52 AM
|
||||
|
||||
|
My D640 is to the point you basically need a hot day or boost pack. I bought it that way hoping it only needed a head, but I think the PO overheating it must have messed up the liners/pistons. It has a bunch of blow by.
What I'm getting at is it may be more than a simple head gasket, but a compression test will tell you a lot. A D600 calls for 337psi min, 10% variance max between cylinders. Service manual: https://www.onlycubcadets.net/forum/...highlight=d640
__________________
Why Farm Half When You Can Farmall? 1282 | 44C Deck, Chains, 42" Blade, Cast Weights, 020" Over K301 * 1711 | 50C Deck, #1 Rear Rototiller w/ Extensions, Sleeve Hitch, KT17S Series II 24302 --> CH18S * 1811 | 46 GT Deck, 42" Blade, Chains, M18 Magnum, Sleeve Hitch * 1782 | 60" #375 Deck, Kubota D640 Diesel * 1862 | #450 Snowblower, M18 Magnum * 782 | Y/W KT17 Series II, Sleeve Hitch * 984 | Y/W Onan/Linamar 20HP, Sims Cab, CAT 0 3 PT w/ Rear PTO, 60" #374 Deck
|
|
#4
04-14-2024, 11:14 AM
|
|||
|
|||
|
Quote:
What gage is needed to do the compression test and where do I get one?
|
|
#5
04-14-2024, 12:24 PM
|
||||
|
||||
|
Is your engine turning over pretty fast when starting?
I'm not sure this will work but I wouldn't expect much for $40. https://www.amazon.com/YUAN-Diesel-C...xoCw9YQAvD_BwE I wonder if your local auto parts store has a loner. Info here. http://www.engineprofessional.com/TB/TB030915-1.pdf
__________________
This ain't no hobby....it's an addiction
|
|
|
|
Cub Cadet is a premium line of outdoor power equipment, established in 1961 as part of International Harvester. During the 1960s, IH initiated an entirely new line of lawn and garden equipment aimed at the owners rural homes with large yards and private gardens. There were a wide variety of Cub Cadet branded and after-market attachments available; including mowers, blades, snow blowers, front loaders, plows, carts, etc. Cub Cadet advertising at that time harped on their thorough testing by "boys - acknowledged by many as the world's worst destructive force!". Cub Cadets became known for their dependability and rugged construction.
MTD Products, Inc. of Cleveland, Ohio purchased the Cub Cadet brand from International Harvester in 1981. Cub Cadet was held as a wholly owned subsidiary for many years following this acquisition, which allowed them to operate independently. Recently, MTD has taken a more aggressive role and integrated Cub Cadet into its other lines of power equipment.
This website and forum are not affiliated with or sponsored by MTD Products Inc, which owns the CUB CADET trademarks. It is not an official MTD Products Inc, website, and MTD Products Inc, is not responsible for any of its content. The official MTD Products Inc, website can be found at: http://www.mtdproducts.com. The information and opinions expressed on this website are the responsibility of the website's owner and/or it's members, and do not represent the opinions of MTD Products Inc. IH, INTERNATIONAL HARVESTER are registered trademark of CNH America LLC
All material, images, and graphics from this site are the property of www.onlycubcadets.net. Any unauthorized use, reproductions, or duplications are prohibited unless solely expressed in writing.
Cub Cadet, Cub, Cadet, IH, MTD, Parts, Tractors, Tractor, International Harvester, Lawn, Garden, Lawn Mower, Kohler, garden tractor equipment, lawn garden tractors, antique garden tractors, garden tractor, PTO, parts, online, Original, 70, 71, 72, 73, 76, SO76, 80, 81, 86, 100, 102, 104, 105, 106, 107, 108,109, 122, 123, 124, 125, 126, 127, 128, 129, 147, 149, 169, 182, 282, 382, 482, 580, 582, 582 Special, 680, 682, 782, 782D, 784, 800, 805, 882, 982, 984, 986, 1000, 1015, 1100, 1105, 1110, 1200, 1250, 1282, 1450, 1512, 1604, 1605, 1606, 1610, 1615, 1620, 1650, 1710, 1711, 1712, 1806, 1810, 1811, 1812, 1912, 1914.
Linear Mode
